Product ID:C-39 CORROSION INHIBITOR
MSDS Date:02/16/2000
FSC:NIIN:Submitter:D DG
Status Code:A
MSDS Number: CLNRB

Emergency Phone: (800) 424-9300

Info Phone: (630) 305-1000

Cage: 89524

Telephone: (630) 305-1000

Cage: 89524

NONE OF THE SUBSTANCES IN THIS PRODUCT ARE HAZARDOUS.

LD50 LC50 Mixture:ORAL, RAT, LD50: 5,840 MG/KG.
Reports of Carcinogenicity:NTP:NO IARC:NO
Health Hazards Acute and Chronic:ACUTE: EYE CONTACT: PARTICLES MAY
SCRATCH EYE SURFACES OR CAUSE MECHANICAL IRRITATION. SKIN CONTACT:
THIS PRODUCT HAS SHARP EDGES WHICH MAY CAUSE CUTS AND ABRASIONS.
INGESTION: NOT A LIKELY ROUTE OF E XPOSURE. NO ADVERSE EFFECTS
EXPECTED. INHALATION: INHALATION OF DRIED PRODUCT DUST MAY CAUSE
IRRITATION. CHRONIC: NO ADVERSE EFFECTS EXPECTED OTHER THAN THOSE
MENTIONED ABOVE.
Explanation of Carcinogenicity:NONE OF THE SUBSTANCES IN THIS PRODUCT
ARE LISTED AS CARCINOGENS BY THE INTERNATIONAL AGENCY FOR RESEARCH
ON CANCER (IARC), THE NATIONAL TOXICOLOGY PROGRAM (NTP) OR THE
AMERICAN CONFERENCE OF GOVERNME NTAL INDUSTRIAL HYGIENISTS (ACGIH).
Effects of Overexposure:EYE CONTACT:IRRITATION. SKIN CONTACT: CUTS AND
ABRASIONS. INHALATION: IRRITATION. INGESTIONNONE EXPECTED. ACUTE: A
REVIEW OF AVAILABLE DATA DOES NOT IDENTIFY ANY SYMPTOMS FROM
EXPOSURE NOT PREVIOUSLY MENTIONED. CHRONIC: A REVIEW OF AVAILABLE
DATA DOES NOT IDENTIFY ANY SYMPTOMS FROM EXPOSURE NOT PREVIOUSLY
MENTIONED.
Medical Cond Aggravated by Exposure:A REVIEW OF AVAILABLE DATA DOES NOT
IDENTIFY ANY WORSENING OF EXISTING CONDITIONS.

First Aid:EYE CONTACT: FLUSH AFFECTED AREA WITH WATER. IF SYMPTOMS
DEVELOP, SEEK MEDICAL ADVICE. SKIN CONTACT: REMOVE CONTAMINATED
CLOTHING. WASH AFFECTED AREA WITH WATER. IF SYMPTOMS DEVELOP, SEEK
MEDICAL ADV ICE. INGESTION: DO NOT INDUCE VOMITING WITHOUT MEDICAL
ADVICE. IF CONSCIOUS, WASH OUT MOUTH. GIVE WATER TO DRINK. IF
SYMPTOMS DEVELOP, SEEK MEDICAL ADVICE. INHALATION: MOVE TO FRESH
AIR, TREAT SYMPTOM ATICALLY. IF SYMPTOMS DEVELOP, SEEK MEDICAL
ADVICE. NOTE TO PHYSICIAN: BASED ON REACTIONS OF PATIENT, THE
PHYSICIAN'S JUDGEMENT SHOULD BE USED TO CONTROL SYMPTOMS AND
CLINICAL CONDITION.

Flash Point:NONE
Extinguishing Media:NOT EXPECTED TO BURN, USE EXTINGUISHING MEDIA
APROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:IN CASE OF FIRE, WEAR A FULL FACE
POSITIVE-PRESSURE SELF CONTAINED BREATHING APPARATUS AND PROTECTIVE
SUIT.
Unusual Fire/Explosion Hazard:MAY EVOLVE OXIDES OF PHOSPHORUS (POX)
UNDER FIRE CONDITIONS. MAY EVOLVE ZINC FUMES UNDER FIRE CONDITIONS.

Spill Release Procedures:SWEEP UP AND SHOVEL. RECLAIM INTO RECOVERY OR
SALVAGE DRUMS. DISPOSE OF MATERIAL IN COMPLIANCE WITH REGULATIONS.
DO NOT CONTAMINATE SURFACE WATER. NOTIFY APPROPRIATE GOVERNMENT,
OCCUPATIONAL HEALTH AN D SAFETY AND ENVIRONMENTAL AUTHORITIES. USE
PERSONAL PROTECTIVE EQUIPMENT RECOMMENDED.

Handling and Storage Precautions:HANDLING: DO NOT TAKE INTERNALLY.
ENSURE ALL CONTAINERS ARE LABELLED. AVOID EYE AND SKIN CONTACT.
AVOID GENERATING DUSTS. STORAGE: STORE SEPARATELY FROM OXIDIZERS.
KEEP IN DRY PLACE.
Other Precautions:(CONTD. FROM "WASTE DISPOSAL") REGULATION FOR ANY
ADDITIONAL HANDLING, TREATMENT, OR DISPOSAL REQUIREMENTS. FOR
DISPOSAL, CONTACT A PROPERLY LICENSED WASTE TREATMENT, STORAGE,
DISPOSAL, OR RECYCLING F ACILITY.

Respiratory Protection:RESPIRATORY PROTECTION IS NOT NORMALLY NEEDED.
AN APPROVED RESPIRATOR MUST BE WORN IF THE OCCUPATIONAL EXPOSURE
LIMIT IS LIKELY TO BE EXCEEDED. A DUST RESPIRATOR MAY BE USED.
Ventilation:GENERAL VENTILATION IS RECOMMENDED. LOCAL EXHAUST
VENTILATION MAY BE NECESSARY WHEN DUST OR MISTS ARE GENERATED.
Protective Gloves:GLOVES TO AVOID CUTS AND ABRASIONS.
Eye Protection:WEAR SAFETY GLASSES WITH SIDE-SHIELDS.
Other Protective Equipment:WEAR STANDARD PROTECTIVE CLOTHING.
Work Hygienic Practices:KEEP AN EYE WASH FOUNTAIN AVAILABLE. KEEP A
SAFETY SHOWER AVAILABLE.
Supplemental Safety and Health
THIS PRODUCT DOES NOT CONTAIN ANY SUBSTANCE THAT HAS AN ESTABLISHED
EXPOSURE LIMIT.

HCC:N1
pH:(5%): 7.5-8.5
Solubility in Water:MODERATE
Appearance and Odor:WHITE GRANULAR; NO ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS (SULFURIC, PHOSPHORIC, NITRIC, HYDROCHLORIC, CHROMIC,
SULFONIC) MAY GENERATE HEAT, SPLATTERING, BOILING, TOXIC VAPORS.
STRONG ALKALIES (AMMONIA AND ITS SOLUTIONS, CARBONATES, SODIUM
HYDROXIDE(CAUSTIC), (CONTD.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS. AVOID
MOISTURE.
Hazardous Decomposition Products:UNDER FIRE CONDITIONS: OXIDES OF
PHOSPHORUS, OXIDES OF SODIUM, DISODIUM OXIDE, ZINC OXIDE.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION WILL NOT
OCCUR.

Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE, IT IS NOT A
HAZARDOUS WASTE AS DEFINED BY THE RESOURCE CONSERVATION AND
RECOVERY ACT (RCRA) 40 CFR 261, SINCE IT DOES NOT HAVE THE
CHARACTERISTICS OF SUBPART C, NOR IS IT LISTED UNDER SUBPART D. AS
A NON-HAZARDOUS WASTE, IT IS NOT SUBJECT TO FEDERAL REGULATION.
CONSU LT STATE OR LOCAL (CONTD. SEE "OTHER PRECAUTIONS")

Toxicological Information:ACUTE ORAL TOXICITY: ORAL, RAT, LD50: 5,840
MG/KG: RATING: NON-HAZARDOUS. CARCINOGENICITY: NONE OF THE
SUBSTANCES IN THIS PRODUCT ARE LISTED AS CARCINOGENS BY THE
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC), THE NATIONAL
TOXICOLOGY PROGRAME (NTP) OR THE AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:ACUTE FISH RESULTS:BLUEGILL SUNFISH: 96 HRS; LC50: 2,611
MG/L. RAINBOW TROUT: 96 HRS; LC50: 84 MG/L. RATING: SLIGHTLY TOXIC.
ACUTE INVERTEBRATE RESULTS: DAPHNIA MAGNA: 48 HRS; LC50: 32 MG/L.
RATING: S LIGHTLY TOXIC. MOBILITY AND BIOACCUMULATION POTENTIAL:
HIGH PHOSPHATE LEVELS IN SURFACE WATER CAN CAUSE EUTROPHICATION
WITH SUBSEQUENT AIGAL BLOOMS AND OXYGEN DEPLETON. IF RELEASED INTO
THE ENVIRONMEN T: CERCLA/SUPERFUND, 40 CFR 117, 302: NOTIFICATION
OF SPILLS OF THIS PRODUCT IS NOT REQUIRED.

Transport Information:THE INFORMATION IN THIS SECTION IS FOR REFERENCE
ONLY AND SHOULD NOT TAKE THE PLACE OF A SHIPPING PAPER (BILL OF
LADING) SPECIFIC TO AN ORDER. PLEASE NOTE THE PROPER SHIPPING NAME
/ HAZARD CLASS MAY V ARY BY PACKAGING, PROPERTIES, AND MODE OF
TRANSPORTATION. TYPICAL PROPER SHIPPING NAMES FOR THIS PRODUCT ARE:
LAND: PRODUCT IS NOT REGULATED DURING TRANSPORTATION; AIR
(ICAO/IATA): NOT REGULATED; MARI NE (IMDG/IMO): NOT REGULATED .

SARA Title III Information:SECTION 302 - EXTREMELY HAZARDOUS SUBSTANCES
(40 CFR 355): THIS PRODUCT DOES NOT CONTAIN SUBSTANCES LISTED IN
APPENDIX A AND B AS AN EXTREMELY HAZARDOUS SUBSTANCE. SECTIONS 311
AND 312 - MSDS REQUIREM ENTS (40 CFR 370): OUR HAZARD EVALUATION
HAS FOUND THAT THIS PRODUCT IS NOT HAZARDOUS UNDER 29 CFR
1910.1200.
Federal Regulatory Information:OSHA HAZARD COMMUNICATION RULE, 29 CFR
1910.1200: BASED ON OUR HAZARD EVALUATION, NONE OF THE SUBSTANCES
IN THIS PRODUCT ARE HAZARDOUS. CERCLA/SUPERFUND, 40 CFR 117,302:
NOTIFICATION OF SPILLS OF THIS PRODUCT IS NOT REQUIRED. THE
CHEMICAL SUBSTANCES IN THIS PRODUCT ARE ON THE TSCA 8(B) INVENTORY
(40CFR 710). FEDERAL WATER POLLUTION CONTROL ACT, CLEAN WTER ACT,
40 CFR 401.15: THIS PRODUCT CONTAINS ZINC THAT IS LISTED IN THE
REGULATION.
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT
DOES NOT CONTAIN SUBSTANCES WHICH REQUIRE WARNING UNDER CALIFORNIA
PROPOSITION 65. MICHIGAN CRITICAL MATERIALS: THIS PRODUCT CONTINS
ZINC THAT IS LISTED IN THE REGULATION. STATE RIGHT-TO-KNOW LAW:
ZINC (CAS # 7440-66-6) IS DISCLOSED FOR COMPLIANCE WITH STATE
RIGHT-TO-KNOW LAWS. WHMIS CLASSIFICATION: NOT CONSIDERED A WHMIS
CONTROLLED PRODUCT. ALL SUBSTANCES I N THIS PRODUCT ARE LISTED ON
THE DOMESTIC SUBSTANCE LIST (DSL), ARE EXEMPT, OR HAVE BEEN
REPORTED IN ACCORDANCE WITH THE NEW SUBSTANCES NOTIFICATION
REGULATIONS.